Deep cryogenic treatment (DCT) is gaining popularity as a treatment used to modify structures obtained during heat or thermo-chemical treatment. The article presents the influence of DCT, carried out during heat treatment before and after gas nitriding processes, on the formation of gas nitrided layers on X153CrMoV12 steel. It was found that the use of DCT between quenching and tempering performed prior to gas nitriding processes, increases the hardness, thickness and wear resistance of the nitrided layers. At the same time, if we apply cryogenic treatment during post-heat treatment of nitrided layers, we also get very high wear resistance and increased thickness of nitrided layers, in comparison with conventional gas nitriding of X153CrMoV12 steel. In this case, DCT significantly increases also the hardness of the core by the transformation of retained austenite and the precipitation of fine carbides of alloying elements.
The paper presents results of coal behaviour during combustion in oxy-fuel atmosphere. The experiment was performed using 3 meter long Entrained Flow Reactor and 1 meter long Drop Tube Reactor. Three hard coals and two lignites were analysed in order to investigate NOx, SO2 emission and fly ash burnout. The measurements were performed along and at the outlet of a combustion chamber for one- and two - stage combustion. In the second stage of the experiment, kinetic parameters for nitrogen evolution during combustion in oxy - fuel and air were calculated and the division of nitrogen into the volatile matter and the char was measured. The conducted experiment showed that emissions in oxy - fuel are lower than those in air.
Phytoplankton composition plays a major role in biogeochemical cycles of the ocean. The intensity of carbon fixation and export is strongly dependent on the phytoplankton community. Yet, the contribution of different types of phytoplankton to the total production on various communities is still poorly understood in the Indian Ocean sector of Southern Ocean (SO). Therefore the variability of chlorophyll- A (Chl-a) and diatoms in the frontal ecosystems of the Indian sector of SO have been investigated along with the sea surface temperature (SST), sea surface wind (SSW), photosynthetically active radiation (PAR), and nutrients datasets for the period of 1998-2012. Combined analysis of in-situ, model and satellite observations indicate that the variability of Chl- A and diatoms were primarily influenced by light and wind. The Chl- A was higher at the sub-Antarctic front (SAF) followed by the sub-tropical front (STF) and the polar front (PF). The diatom concentration was higher at the SAF followed by the PF and STF. Maximum concentration of Chl- A and diatoms commonly observed at the SAF region are probably due to the moderate PAR, SST and wind. Dominance of diatoms at the PF may be attributed to their adaptability for low light conditions. The results from this study in the frontal ecosystems would help to understand the biogeochemical cycle of the Indian sector of the SO.